亚硫酸盐预处理对蔗渣酶解效率的影响

doi:10.3969/j.issn.0253-2417.2016.05.013

摘要/Abstract

摘要： 为了破坏蔗渣的抗降解性，获得高的酶解效率，采用亚硫酸盐法对蔗渣进行预处理，探讨亚硫酸氢钠用量对蔗渣理化性质、表面磺酸基含量（磺化度）及酶解效率的影响，并进一步分析了磺化度对酶解效率的影响。结果显示：不同亚硫酸氢钠用量蔗渣的结晶度（I_Cr）变化不显著，但预处理后蔗渣纤维素结晶区相对含量上升，半纤维素含量减少。50 g蔗渣，按固液比1：8（g：mL）加入1.1%的稀硫酸，亚硫酸氢钠加入量（以绝干蔗渣计）为8%，在160℃条件下反应30 min时制得的蔗渣其表面磺酸基最多，达131.73 μmol/g。在2%干蔗渣，7.5 FPU/g（以干蔗渣计），50℃，72 h酶解条件下，对不同磺化度的蔗渣进行酶解，结果显示酶解效率随底物的磺化度升高而升高，最高综纤维素水解效率可达83.76%。研究表明：蔗渣的酶解效率与磺酸基团的含量呈正相关，而与蔗渣中纤维素的结晶度关系不明显；酸性亚硫酸盐法可除去绝大部分半纤维素，破坏蔗渣抗降解性，促进酶解效率。

关键词: 蔗渣, 亚硫酸盐预处理, 纤维素酶水解, 磺化度, 结晶度

Abstract: To overcome the anti-degradation of sugarcane bagasse, sulfite pretreatment (SPORL) was used and the effects of sodium bisulfite concentration on the physicochemical characteristics, the sulfonic acid group on the surface(sulfonation degree) and hydrolysis efficiency of sugarcane bagasse were investigated, and the effect of sulfonation degree on hydrolysis efficiency of bagasse was further studied. The results revealed that different sodium bisulfite concentration had no significant influences on the crystrallinity index (I_Cr) of bagasse and bagasse samples treated by SPORL had more crystalline cellulose and less hemicellulose. Besides, 50 g oven bagasse with 1:8 solid-liquid ratio was treated by adding 8% sodium bisulfite(based on the dry bagasse) at 160℃ for 30 min and 131.73 μmol/g sulfonic group was obtained. The hydrolyses of bagasse with different degree of sulfonation were conducted at 50℃ for 72 h as 7.5 FPU/g dry bagasse (based on 2% dry bagasse). The results demonstrated that the enzymatic efficiency increased with the increase of degree of sulfonation and the highest hydrolysis efficiency of holocellulose was 83.76%. The study indicated that the hydrolysis efficiency of bagasse was positively related to sulfonic group content in bagasse and had no significant relationship with crystallinity degree of bagasse. Low-pH SPORL could remove most hemicellulose in bagasse, and the anti-degradation of bagasse was overcome. Finally, the enzymatic hydrolysis of lignocellulose was enhanced as well.

Key words: sugarcane bagasse, SPORL, enzyme hydrolysis of cellulose, degree of sulfonation, crystallinity degree

中图分类号:

TQ353

刘志佳, 董益帆, 兰天晴. 亚硫酸盐预处理对蔗渣酶解效率的影响[J]. 林产化学与工业, 2016, 36(5): 89-94.

LIU Zhi-jia, DONG Yi-fan, LAN Tian-qing. Effect of Sulfite Pretreatment on Hydrolysis Efficiency of Sugarcane Bagasse[J]. Chemistry and Industry of Forest Products, 2016, 36(5): 89-94.

参考文献

[1] 赵风云,杨鑫,黄淑君,等.以蔗渣和棉籽壳为基质的灵芝酶活性及其营养对比研究[J].现代食品科技,2015,31(1):84-89. ZHAO Feng-yun,YANG Xin,HUANG Shu-jun,et al.Comparison of enzyme activity and nutrients of ganoderma lucidum cultivated on bagasse and cottonseed hull substrates[J].Modern Food Science and Technology,2015,31(1):84-89.
[2] 马斌,储秋露,朱均均,等.4种木质纤维素预处理方法的比较[J].林产化学与工业,2013,33(2):25-30. MA Bin,CHU Qiu-lu,ZHU Jun-jun,et al.Four kinds of pretreatment methods for lignocellulosics[J].Chemistry and Industry of Forest Products,2013,33(2):25-30.
[3] MARGEOT A,HAHN-HAGERDAL B,EDLUND M,et al.New improvements for lignocellulosic ethanol[J].Current Opinion in Biotechnology,2009,20(3):372-380.
[4] ZHU Jun-yong,PAN Xue-jun,WANG Gao-sheng,et al.Sulfite pretreatment (SPORL) for robust enzymatic saccharification of spruce and red pine[J].Bioresource Technology,2009,100(8):2411-2418.
[5] LI Shuai,YANG Quan-he,ZHU Jun-yong,et al.Comparative study of SPORL and dilute-acid pretreatments of spruce for cellulosic ethanol production[J].Bioresource Technology,2010,101(9):3106-3114.
[6] LAN Tian-qing,LOU Hong-ming,ZHU Jun-yong.Enzymatic saccharification of lignocelluloses should be conducted at elevated pH 5.2-6.2[J].Bioenergy Research,2013,6(2):476-485
[7] WANG Zhao-jiang,LAN Tian-qing,ZHU Jun-yong.Lignosulfonate and elevated pH can enhance enzymatic saccharification of lignocelluloses[J].Biotechnology for Biofuels,2013,6(1):9-19.
[8] LOU Hong-ming,ZHU Jun-yong,LAN Tian-qing,et al.pH-Induced lignin surface modification to reduce nonspecific cellulase binding and enhance enzymatic saccharification of lignocelluloses[J].Chemsuschem,2013,6(5):919-927.
[9] SLUITER A,HAMES B,RUIZ R,et al.Determination of structural carbohydrates and lignin in biomass[S].United States:National Renewable Laboratory Golden,2005.
[10] 李坤.香蕉茎和甘蔗渣预处理及其纤维素酶解糖化的基础研究[D].广州:华南理工大学硕士学位论文,2010. LI Kun.Study on pretreatment and cellulase saccharification for both banana pseudo-stem and bagasse[D].Guangzhou:Master Degree Thesis of South China University of Technology,2010.
[11] 武书彬,徐绍华.蔗渣乙醇预处理及其对酶解的影响[J].华南理工大学学报:自然科学版,2014,42(7):124-131. WU Shu-bin,XU Shao-hua.Ethanol pretreatment of sugarcane bagasse and its effect on enzymatic hydrolysiss[J].Journal of South China University of Technology:Natural Science Edition,2014,42(7):124-131.
[12] 张超.SPORL法与稀酸法对木质生物质预处理效果的研究[D].天津:天津大学博士学位论文,2013. ZHANG Chao.Study on SPORL and dilute-acid pretreatment for woody biomass[D].Tianjin:Doctoral Dissertation of Tianjin University,2013.
[13] LIAO Da-zheng,HUANG Zu-qiang,HU Hua-yu,et al.Microscopic structure and properties changes of cassava stillage residue pretreated by mechanical activation[J].Bioresource Technology,2011,102(17):7953-7958.
[14] 李计彪,武书彬,徐绍华.木质素磺酸盐的化学结构与热解特性[J].林产化学与工业,2014,34(2):23-28. LI Ji-biao,WU Shu-bin,XU Shao-hua.Chemical structure and thermochemical property of lignin sulfonate[J].Chemistry and Industry of Forest Products,2014,34(2):23-28
[15] SINDHU R,BINOD P,SATYANAGALAKSHMI K,et al.Formic acid as a potential pretreatment agent for the conversion of sugarcane bagasse to bioethanol[J].Applied Biochemistry & Biotechnology,2010,162(8):2313-2323.
[16] GAO Yue-shu,XU Jing-liang,ZHANG Yu,et al.Effects of different pretreatment methods on chemical composition of sugarcane bagasse and enzymatic hydrolysis[J].Bioresource Technology,2013,144(5):396-400.
[17] ZHANG Jing-zhi,MA Xing-xing,YU Jian-liang,et al.The effects of four different pretreatments on enzymatic hydrolysis of sweet sorghum bagasse[J].Bioresource Technology,2011,102(6):4585-4589.
[18] FUENTES L L G,RABELO S C,FILHO R M,et al.Kinetics of lime pretreatment of sugarcane bagasse to enhance enzymatic hydrolysis[J].Applied Biochemistry and Biotechnology,2011,163(5):612-625.
[19] QIU Zeng-hui,AITA G M,WALKER M S.Effect of ionic liquid pretreatment on the chemical composition,structure and enzymatic hydrolysis of energy cane bagasse[J].Bioresource Technology,2012,117(4):251-256.
[20] REZENDE C A,LIMA M A D,MAZIERO P,et al.Chemical and morphological characterization of sugarcane bagasse submitted to delignification process for enhanced enzymatic digestibility[J].Biotechnology for Biofuels,2011,4:54-72.
[21] 陈理恒,付时雨,钟林新,等.亚硫酸盐制浆方法用于蔗渣生物酶解的预处理研究[J].中华纸业,2011,32(14):32-36. CHEN Li-heng,FU Shi-yu,ZHONG Xin-lin,et al.Pretreatment study on bagasse for enzymatic hydrolysis with sulfite pulping method[J].China Pulp & Paper Industry,2011,32(14):32-36.
[22] 吴连祯,张俊华,林鹿,等.亚硫酸盐蔗渣浆的纤维素酶水解及其机理研究[J].林产化学与工业,2010,30(1):33-38. WU Lian-zhen,ZHANG Jun-hua,LIN Lu,et al.Study on hydrolysis and hydrolysis mechanism of bagasse sulfite pulp by cellulase[J].Chemistry and Industry of Forest Products,2010,30(1):33-38.
[23] ZHU Jun-yong,PAN Xue-jun,ZALESNY R S.Pretreatment of woody biomass for biofuel production:Energy efficiency,technologies,and recalcitrance[J].Applied Microbiology & Biotechnology,2010,87(3):847-857.