生物质热裂解反应器对镍/木炭催化剂重复使用过程中积炭的影响研究

doi:10.3969/j.issn.0253-2417.2015.02.003

林产化学与工业 ›› 2015, Vol. 35 ›› Issue (2): 17-24.doi: 10.3969/j.issn.0253-2417.2015.02.003

生物质热裂解反应器对镍/木炭催化剂重复使用过程中积炭的影响研究

邵晴莉, 左宋林, 肖志良, 夏海岸

南京林业大学化学工程学院, 江苏南京 210037

收稿日期:2014-03-13 出版日期:2015-04-25 发布日期:2015-04-24
通讯作者: 左宋林,教授,博士生导师,主要从事生物质热解及活性炭的研究工作;E-mail:zslnl@hotmail.com。 E-mail:zslnl@hotmail.com
作者简介:邵晴莉(1989-),女,江苏南通人,硕士生,主要从事生物质能源与炭材料研究
基金资助:
国家自然科学基金资助项目(31270621)

Effect of Biomass Pyrolysis Reactor on Carbon Deposition of Ni/Char Catalysts during Repeat Experiments

SHAO Qing-li, ZUO Song-lin, XIAO Zhi-liang, XIA Hai-an

College of Chemical Engineering, Nanjing Forest University, Nanjing 210037, China

Received:2014-03-13 Online:2015-04-25 Published:2015-04-24

摘要/Abstract

摘要： 为了研究生物质热解气化过程中,反应器类型对镍基催化剂的积炭和使用寿命的影响,以杉木屑为原料,研究了Ni/木炭催化剂分别在二段式和三段式热裂解反应器内重复使用次数对杉木屑热裂解产物及其催化剂质量的影响规律。结果表明:在杉木屑热裂解过程中,Ni/木炭催化剂上会同时发生炭的沉积和炭的氧化消耗2个过程,其质量的变化受这2个过程共同的影响,且镍基活性中心上的积炭比载体木炭更难以被氧化消耗。沉积在Ni/木炭催化剂上的炭主要是以纳米碳纤维的形式存在,且纳米碳纤维覆盖在金属镍上。在二段式反应器中,催化剂的质量是先减少,然后增加,再减少;而在三段式中,则是不断减少。采用三段式生物质热裂解反应器不仅可以显著延长Ni/木炭催化剂的使用寿命,而且可以充分利用热解气化过程所产生的副产物固体炭,从而降低生物质热解气化的催化剂使用成本。

关键词: 生物质热解, Ni/木炭催化剂, 使用寿命, 积炭

Abstract: In order to investigate the effect of the type of reactor on carbon deposition and service life of Ni based catalysts in the process of biomass pyrolysis, a Ni/char catalyst was reused in a two-stage reactor and a three-stage reactor. The effects of pyrolytic volatiles from fir wood sawdust on the weight of catalyst were also studied. The results showed that the changes in the Ni/char weight depended on the two pathways, i.e., the carbon deposition on the catalyst by the thermal cracking, and carbon losing by oxidation in the cracking process of fir wood sawdust. It was found that the carbon deposited on the Ni/char catalyst was more difficult to be oxidized than the char used as the carrier. The deposited carbon was presented in a form of carbon nanofibers. The Ni/char catalyst has longer cycle life in the three-stage reactor than that in the two-stage one. As a result, the three-stage reactor was recommended in the process of biomass gasification due to remarkable reduction of the cost in biomass gasification.

Key words: biomass pyrolysis, Ni/char catalyst, service life, carbon deposition

中图分类号:

TQ35
TQ426.8

邵晴莉, 左宋林, 肖志良, 夏海岸. 生物质热裂解反应器对镍/木炭催化剂重复使用过程中积炭的影响研究[J]. 林产化学与工业, 2015, 35(2): 17-24.

SHAO Qing-li, ZUO Song-lin, XIAO Zhi-liang, XIA Hai-an. Effect of Biomass Pyrolysis Reactor on Carbon Deposition of Ni/Char Catalysts during Repeat Experiments[J]. Chemistry and Industry of Forest Products, 2015, 35(2): 17-24.

参考文献

[1] 肖志良, 左宋林.生物质气化与催化剂的研究进展[J].生物质化学工程, 2012, 46(1):39-44. XIAO Zhi-liang, ZUO Song-lin.Research progress on biomass gasification and catalysts[J].Biomass Chemical Engineering, 2012, 46(1):39-44.
[2] HE Mao-yun, XIAO Bo, LIU Shi-ming, et al.Hydrogen-rich gas from catalytic steam gasification of municipal solid waste (MSW):Influence of steam to MSW ratios and weight hourly space velocity on gas production and composition[J].International Journal of Hydrogen Energy, 2009, 34(5):2174-2183.
[3] 侯斌, 吕子安, 李晓辉, 等.生物质热解产物中焦油的催化裂解[J].燃料化学学报, 2001, 29(1):70-75. HOU Bin, LV Zi-an, LI Xiao-hui, et al.Catalytic cracking of tar from biomass pyrolysis[J].Journal of Fuel Chemistry and Technology, 2001, 29(1):70-75.
[4] ERKIAGA A, LOPEZ G, AMUTIO M, et al.Steam gasification of biomass in a conical spouted bed reactor with olivine and γ-alumina as primary catalysts[J].Fuel Processing Technology, 2013, 116:292-299.
[5] LANCEE R J, DUGULAN A I, THVNE P C, et al.Chemical looping capabilities of olivine, used as a catalyst in indirect biomass gasification[J].Applied Catalysis B:Environmental, 2014, 145:216-222.
[6] LI Zhi-kun, HU Xun, ZHANG Li-jun, et al.Steam reforming of acetic acid over Ni/ZrO₂ catalysts:Effects of nickel loading and particle size on product distribution and coke formation[J].Applied Catalysis A:General, 2012, 418:281-289.
[7] DANILOVA M M, FEDOROVA Z A, ZAIKOVSKII V I, et al.Porous nickel-based catalysts for combined steam and carbon dioxide reforming of methane[J].Applied Catalysis B:Environmental, 2014, 147:858-863.
[8] 尤占平, 由世俊, 李宪莉, 等.生物质炭催化裂解焦油的性能研究[J].可再生能源, 2011, 29(3):39-42. YOU Zhan-ping, YOU Shi-jun, LI Xian-li, et al.Study on biomass char on catalytic pyrolysis performance of tar[J].Renewable Energy Resources, 2011, 29(3):39-42.
[9] 杜丽娟, 李建芬, 肖波, 等.生物质催化裂解制合成气的研究[J].化学工程师, 2008, 153(6):4-9. DU Li-juan, LI Jian-fen, XIAO Bo, et al.Study on syn-gas production from biomass catalytic pyrolysis[J].Chemical Engineer, 2008, 153(6):4-9.
[10] 张万东.稀土改性Ni基催化剂上CO₂/CH₄重整制合成气的研究[D].天津:天津大学博士学位论文, 2006. ZHANG Wan-dong.Studies on CO₂ reforming of methane to syngas over ni-based catalysts modified by rare earth oxide[D].Tianjin:Doctoral Dissertation of Tianjin University, 2006.
[11] DOU Bin-lin, GAO Jin-sheng, SHA Xing-zhong, et al.Catalytic cracking of tar component from high-temperature fuel gas[J].Applied Thermal Engineering, 2003, 23(17):2229-2239.
[12] 吕鹏梅, 常杰, 付严, 等.生物质流化床催化气化制取富氢燃气[J].太阳能学报, 2004, 25(6):769-775. LV Peng-mei, CHANG Jie, FU Yan, et al.Producing gas of rich hydrogen in the fluidized bed with biomass catalytic gasification[J].Acta Energiae Solaris Sinica, 2004, 25(6):769-775.
[13] LI Xian-cai, WU Min, LAI Zhi-hua, et al.Studies on nickel-based catalysts for carbon dioxide reforming of methane[J].Applied Catalysis A:General, 2005, 290(1/2):81-86.
[14] SONG Yao, WANG Yi, HU Xun, et al.Effects of volatile-char interactions on in situ destruction of nascent tar during the pyrolysis and gasification of biomass.Part I.Roles of nascent char[J].Fuel, 2014, 122:60-66.
[15] HAN Jiang-ze, WANG Xing-dong, YUE Jun-rong, et al.Catalytic upgrading of coal pyrolysis tar over char-based catalysts[J].Fuel Processing Technology, 2014, 122:98-106.
[16] EI-RUB Z A, BRAMER E A, BREM G.Experimental comparison of biomass chars with other catalysts for tar reduction[J].Fuel, 2008, 87(10/11):2243-2252.
[17] 孙青松.两段式生物质催化裂解-炭基催化剂的研究[D].上海:华东理工大学硕士学位论文, 2010. SUN Qing-song.Catalytic cracking of biomass using char-based catalyst in a two-stage fixed-bed reactor[D].Shanghai:Master Degree Thesis of East China University of Science and Technology, 2010.
[18] CAO Jing-pei, SHI Peng, ZHAO Xiao-yan, et al.Catalytic reforming of volatiles and nitrogen compounds from sewage sludge pyrolysis to clean hydrogen and synthetic gas over a nickel catalyst[J].Fuel Processing Technology, 2014, 123:34-40.
[19] XIE Qing-long, KONG Si-fang, LIU Yang-sheng, et al.Syngas production by two-stage method of biomass catalytic pyrolysis and gasification[J].Bioresource Technology, 2012, 110:603-609.
[20] 贺茂云, 肖波, 胡智泉, 等.镍基催化剂的制备及其对垃圾气化产氢的催化活性[J].中国环境科学, 2009, 29(4):391-396. HE Mao-yun, XIAO Bo, HU Zhi-quan, et al.Preparation of Ni-based catalysts and evaluation of their catalytic activity in gasification of municipal solid waste (MSW) to hydrogen[J].China Environmental Science, 2009, 29(4):391-396.
[21] SHEN Ya-fei, ZHAO Pei-tao, SHAO Qin-fu, et al.In-situ catalytic conversion of tar using rice husk char-supported nickel-iron catalysts for biomass pyrolysis/gasification[J].Applied Catalysis B:Environmental, 2014, 152/153:140-151.
[22] PHUHIRAN C, TAKARADA T, CHAIKLANGMUANG S.Hydrogen-rich gas from catalytic steam gasification of eucalyptus using nickel-loaded Thai brown coal char catalyst[J].International Journal of Hydrogen Energy, 2014, 39(8):3649-3656.
[23] 吕香玉.甲烷干式重整镍基催化剂的研究[D].北京:北京化工大学硕士学位论文, 2012. LV Xiang-yu.Study on nickel-based catalysts for dry reforming of methane[D].Beijing:Master Degree Thesis of Beijing University of Chemical Technology, 2012.
[24] GUCZI L, STEFLER G, GESZTI O, et al.Methane dry reforming with CO₂:A study on surface carbon species[J].Applied Catalysis A:General, 2010, 375(2):236-246.
[25] PARIZOTTO N V, ROCHA K O, DAMYANOVA S, et al.Alumina-supported Ni catalysts modified with silver for the steam reforming of methane:Effect of Ag on the control of coke formation[J].Applied Catalysis A:General, 2007, 330:12-22.

生物质热裂解反应器对镍/木炭催化剂重复使用过程中积炭的影响研究

Effect of Biomass Pyrolysis Reactor on Carbon Deposition of Ni/Char Catalysts during Repeat Experiments

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 2

编辑推荐

Metrics

本文评价

关于本刊

投稿指南

在线期刊

相关单位

联系我们

[1]	李三平, 孙雪, 王述洋. 内胆式双热型生物质热解反应器内传热过程建模分析[J]. 林产化学与工业, 2017, 37(1): 73-80.
[2]	李三平, 王述洋, 孙雪, 曹有为. 新型内胆式双热型生物质热解反应器的设计[J]. 林产化学与工业, 2014, 34(1): 49-56.