欢迎访问《林产化学与工业》，
林产化学与工业

林产化学与工业 ›› 2010, Vol. 30 ›› Issue (3): 83-87.

• 研究报告 • 上一篇    下一篇

玫瑰精油超临界二氧化碳萃取的试验研究

方向, 朱跃钊, 凌祥, 廖传华   

  1. 南京工业大学 机械与动力工程学院, 江苏 南京 210009
  • 收稿日期:2009-09-10 修回日期:1900-01-01 出版日期:2010-06-30 发布日期:2010-06-30
  • 通讯作者: 朱跃钊,男,教授,博士生导师,从事先进能源及装备技术的研究;E-mail:zyz@njut.edu.cn。

Study on Supercritical Carbon Dioxide Extraction of Rose Essential Oil

FANG Xiang, ZHU Yue-zhao, LING Xiang, LIAO Chuan-hua   

  1. College of Mechanical and Power Engineering, Nanjing University of Technology, Nanjing 210009, China
  • Received:2009-09-10 Revised:1900-01-01 Online:2010-06-30 Published:2010-06-30

PDF (PC)

823

摘要： 采用正交试验和单因素试验相结合的方法对超临界CO2萃取法提取玫瑰精油的工艺进行了研究。得到了最佳萃取条件为:压力20MPa,温度65℃,粒径250μm,CO2循环流量25L/h,此条件下玫瑰精油的得率可达到5.2257%。各因素的影响大小依次为:粒径、流量、温度、压力。试验还在萃取釜中布置了气体分布器。实验结果表明,在小粒径的条件下气体分布器可以更加有效的增加精油的得率,且不会影响到萃取釜中流体的流动速度。

关键词: 超临界CO2萃取, 玫瑰, 精油

Abstract: The process of extracting essential oil from rose flowers(Rosa rugosa var.plena)using supercritical carbon dioxide was studied. Analysis results via orthogonal experiment and single-factor experiment were obtained. The results showed that the optimum extraction conditions were as follows: particle size 250μm, CO2 circulation flow rate 25L/h, temperature 65℃ and pressure 20MPa. Under these conditions, the yield of rose essential oil can reach 5.225 7% The yield of essential oil was significantly affected by particle size, supercritical fluid flow rate, extraction temperature and pressure. The result also showed that, under the condition of small particle size, gas distributor could increase the yield effectively, which did not influence the fluid flow speed in the extraction vessel.

Key words: supercritical CO2 extraction, rose, essential oil

中图分类号: 

版权所有 © 中国林业科学研究院林产化学工业研究所　苏ICP备08107184号-3