欢迎访问《林产化学与工业》，
林产化学与工业

林产化学与工业 ›› 2012, Vol. 32 ›› Issue (5): 69-76.

• 1研究报告 • 上一篇    下一篇

绿液预处理麦秆纤维素酶水解的研究

赵士明, 陆青山, 储秋露, 余世袁   

  1. 南京林业大学 化学工程学院,江苏省生物质绿色燃料与化学品重点实验室, 江苏 南京 210037
  • 收稿日期:2011-10-24 修回日期:1900-01-01 出版日期:2012-10-30 发布日期:2012-10-30
  • 通讯作者: 余世袁,博士生导师,研究领域为林产资源生物化学加工和利用;E-mail:syu@njfu.edu.cn。

Enzymatic Hydrolysis of Wheat Straw Pretreated by Green Liquor

ZHAO Shi-ming, LU Qing-shan, CHU Qiu-lu, YU Shi-yuan   

  1. College of Chemical Engineering,Nanjing Forestry University,Jiangsu Key Lab of Biomass-based Green Fuel & Chemicals, Nanjing 210037, China
  • Received:2011-10-24 Revised:1900-01-01 Online:2012-10-30 Published:2012-10-30

PDF (PC)

752

摘要： 研究了绿液预处理对麦秆酶水解的影响。比较了不同绿液预处理条件下麦秆的浆得率、成分组成与纤维素酶解率,结果表明,预处理条件越剧烈,原料损失越大,而木质素脱除率越高,且在相同酶水解条件下,纤维素酶解率却越高,其中适宜的条件是预处理温度 150 ℃,总碱量8 %(Na2O计,对绝干原料)和硫化度40 %,浆得率 62.0 %,葡聚糖、木聚糖和木质素质量分数 50.0 %、 18.9 % 和 16.2 %,葡萄糖和木糖得率分别为 74.2 % 和 73.5 %。考察了质量浓度和酶用量对绿液预处理麦秆酶水解的影响,优化了商品纤维素酶酶系结构和Tween-80的添加量,表明绿液预处理麦秆纤维素酶水解的适宜条件为质量浓度 100 g/L,纤维素酶用量 15 FPU/g(以纤维素计,下同), β-葡萄糖苷酶 9 IU/g,木聚糖酶 30 IU/g,Tween-80 0.05 g/g。在以上条件下,酶水解 72 h,葡萄糖得率和木糖得率分别达到了 82.5 % 和 77.8 %,是优化前的2.6和1.6倍。

关键词: 麦秆, 纤维素酶水解, 绿液预处理

Abstract: The wheat straw pretreated by green liquor was hydrolyzed under the exist of enzymes. The pulp yield, chemical composition and enzymatic hydrolysis yield under different green liquor pretreatment conditions were studied. The results indicated that the pulp with higher weight loss and delignification were obtained as more severe condition was applied in pretreatment, and the enzymatic hydrolysis yield was higher in the same enzymatic hydrolysis conditions. The proper pretreatment was conducted at 150℃ as the total alkali charge and sulfidity were 8 % and 40 % while pulp yield was 62.0 %, the content of glucan, xylan and lignin was 50.0 %, 18.9 % and 16.2 %, glucose yield and xylose yield was 74.2 % and 73.5%, repectively. The effects of mass concentration and enzyme dosage on wheat straw pretratment by green liquor were investigated. The enzyme system and addition amount of Tween-80 were optimized. The optimum enzymatic hydrolysis conditions of wheat straw by green liquor were 100 g/L mass concentration, 15 FPU/g cellulase dosages, 9 IU/g β-glucosidase, 30 IU/g xylanase and 0.05 g/g Tween-80. The glucose yield and xylose yield were 82.5 % and 77.8 % respectively under the optimum pretreatment conditions. They were 2.6 times and 1.6 times of those without treatment.

Key words: wheat straw, enzymatic hydrolysis, green liquor pretreatment

中图分类号: 

版权所有 © 中国林业科学研究院林产化学工业研究所　苏ICP备08107184号-3